Gravel in Old Appleton, MO

Delivered gravel prices vary by material and supplier, but in West Missouri you can expect raw material to run about $20 to $40 per ton and delivered prices commonly fall in the $35 to $75 per ton range depending on distance and truck fees. A rule of thumb is 1 cubic yard equals about 1.3 to 1.5 tons for most crushed stone; using 1.4 tons/yd3, delivered gravel typically costs roughly $50 to $105 per cubic yard. Final price depends on stone type, delivery distance, minimum order (Hello Gravel minimum: 3 tons), and whether spreading is requested.

Common local types include crushed limestone (good all-purpose base), bankrun or crusher run (a mixture of fines and stone for base layers), #57 crushed stone (popular surface stone for driveways), and pea gravel (decorative, good for walkways). Suppliers in the Old Appleton area may also offer river rock and washed stone; each has different drainage and compaction characteristics, so choose by project (base, surface, or decoration).

Recommended depths depend on use: pathways and decorative areas: 2 to 3 inches of surface stone over a firm base; residential driveways: a 4 to 8 inch total compacted section (commonly a 4-6 inch compacted base of crusher run plus a 2-3 inch wearing course of #57). Heavy-use or rural driveways with trucks often need 8 to 12 inches of compacted base. Always factor in local clay subgrades and drainage; you may need extra depth and geotextile to reduce rutting.

Freeze-thaw causes frost heave and creates ruts and washout where water cannot drain. To minimize issues in Old Appleton, install a well-compacted base, build a crowned center for runoff, use proper drainage (ditches or French drains), and consider geotextile fabric over clay soils. Regular maintenance—seasonal regrading and adding fresh stone—also reduces long-term damage from freeze-thaw cycles.

Hello Gravel connects you with local suppliers who commonly deliver by tri-axle dump truck; minimum orders start at 3 tons. Delivery radius varies by supplier but most operate within roughly 10 to 50 miles of Old Appleton; longer hauls may increase per-ton freight. Some drivers will offer tailgate spreading at their discretion—request it at checkout but note there are no guarantees.

Calculate area in square feet and decide the target depth in inches, then use the rule: cubic yards = (square feet * depth inches) / 324. To convert to tons, multiply cubic yards by about 1.4 (typical crushed stone density). Example: a 12 ft by 40 ft driveway at 4 inches deep is 480 sqft, which is about 5.9 cubic yards or roughly 8.3 tons.

On clay soils, start with a stabilized base: lay geotextile fabric to separate the clay, then a compacted layer of crusher run or bankrun for load-bearing. Use a clean, angular surface stone such as #57 or 3/4u0022 crushed stone on top to promote drainage and avoid fine silt. Adding perimeter drains or swales and maintaining a slope away from structures will improve performance in wet seasons.

Gravel has the lowest upfront cost but higher ongoing maintenance; installed gravel driveways often cost least per square foot but need periodic regrading and regraveling every few years. Asphalt and concrete cost more up front (asphalt and concrete commonly run several times the cost of gravel per square foot) but usually last longer between major repairs; asphalt typically needs sealcoating and repairs every 10 to 20 years, concrete can last 25+ years with less frequent maintenance. Which is most cost-effective depends on expected traffic, desired longevity, and maintenance budget.

Permitting and HOA rules vary by location. For Old Appleton, check with the local county or township building/planning office and any neighborhood HOA before you start—some jurisdictions or HOAs have surface, setback, or drainage requirements. If you need help finding local contact information, Hello Gravel's team can point you in the right direction.

Light maintenance like filling potholes and regrading is commonly needed annually or after heavy storms, while adding fresh surface stone is often done every 2 to 5 years depending on traffic. Typical contractor costs vary, but expect material prices around $20 to $40 per ton and small regrading or pothole repairs ranging from $100 to several hundred dollars; full regraveling of a long drive will cost more. Costs are affected by haul distance from suppliers to Old Appleton and by how much new material you add.