Gravel in Johnson County, TN

Delivery costs in Johnson County vary by supplier, load size, and distance but many local suppliers (and Hello Gravel partners) offer free or low-cost delivery on orders above the 3-ton minimum; small delivery fees of $25-$75 can apply in remote areas. Tailgate spreading when requested is often charged extra or offered at the driver’s discretion; typical contractor or driver-assisted spreading ranges from about $50 to $150 depending on job complexity. Always request a quote in checkout and note that final costs depend on access, site conditions, and whether a loader or extra labor is needed.

For hilly, rain-prone sites in Johnson County, angular crushed stone and mixes with fines (for example crusher run or 3/4u0022 minus) perform best because they lock together and resist washout. Avoid smooth, rounded stones like pea gravel on slopes since they can shift and become slippery when wet. Combine good surface stone with proper drainage, retaining edges, or terraces for reliable slope performance.

A common rule: one cubic yard covers about 108 sq ft at 3u0022 depth and weighs roughly 1.4 tons. Rough estimates at 3u0022 finished depth: one-car (10x20) about 2.5-3 tons, two-car (20x20) about 5-6 tons, and three-car (30x20) about 8-9 tons. Because of compaction, slope, and local soil in Johnson County, order 10-15% extra and remember Hello Gravel's minimum order is 3 tons.

Many Johnson County contractors recommend gravel for very rural, low-traffic driveways because it drains well, is easy to repair after freeze-thaw cycles, and suits uneven terrain. Asphalt provides a smoother, lower-dust surface and can reduce long-term maintenance if installed over a properly prepared, well-drained base, but it costs more up front and can be vulnerable to drainage problems without good subgrade work. Choice usually depends on traffic levels, budget, and willingness to maintain the surface.

Inspect your driveway after heavy rains and the winter thaw; common maintenance includes annual grading to fix ruts and reapplying 1-3 tons of gravel every 2-3 years for typical residential driveways. Hiring a contractor for grading or minor repairs in Johnson County commonly runs $100-$300 per visit, while material costs for added gravel typically range by ton depending on the mix. Good drainage, edge restraint, and occasional fresh top dressing reduce long-term costs.

Rules vary: most rural Johnson County parcels allow gravel driveways, but some municipalities, townships, or homeowners associations may have restrictions on surface materials, curb-to-road transitions, or sightlines. Before ordering, check with Johnson County planning/road department and your HOA (if applicable) for permitting or apron requirements, and confirm any setback or surfacing rules. Hello Gravel recommends verifying regulations as part of project planning.

Local suppliers in the Tennessee region commonly offer screened, washed, and crushed stone products; screened gravel is sorted for size while washed gravel is cleaned of fines and clay. Typical bulk prices in rural Johnson County usually vary roughly between $25 and $60 per ton depending on product and quality, with premium washed or decorative gravels at the higher end; prices vary by supplier, season, and truck access. For exact pricing and product availability, request a quote on Hello Gravel and check regional photos and notes before ordering.

Yes—gravel is commonly used for rural parking and RV pads in Johnson County when properly prepared: excavate poor topsoil, lay geotextile fabric over soft ground, install a 4-8u0022 compacted base of crushed stone (dense-graded material like crusher run), and finish with 2-3u0022 of surface gravel. Proper grading, compaction, and drainage trenches prevent rutting and pooling in the area's frequent rain. Contractor base-prep charges vary by access and size, so get a site-specific quote.

Both crushed stone and crushed concrete can control erosion on slopes; crushed stone (angular, clean rock) tends to offer longer-term stability and consistent drainage, while crushed concrete can be a cost-effective recycled option but may contain fines that affect permeability. On steep, rain-prone Johnson County slopes, pair any aggregate with erosion controls like terracing, geotextile, silt fences, and vegetation to reduce runoff. A local contractor can recommend the best mix and placement for slope stability.

For heavy truck access in Johnson County, use a dense-graded base such as 3/4u0022 minus crusher run, Type II stone, or an ABC aggregate with plenty of fines to lock the base together; compact it to 6-12u0022 depending on load frequency. Place the load-bearing aggregate over a well-drained subgrade and consider geotextile fabric to prevent mixing with native soils. For very frequent heavy loads, consult a civil contractor—paving or engineered base sections may be the best long-term solution.